How to repair the dry battery inside the electric vehicle

The battery repair has been used mainly for or is using the old batteries in the process of complete series of repair, maintenance, renovation and other process. Now all the car cannot leave the battery, including cars, electric cars, motorcycles, electric tricycle, trucks, ships, agricultural vehicles and so on. Our equipment for the lead-acid battery can be used on the repair work.

Battery repair battery sulfide, active substances, mainly for the plate of softening, hardening and a series of problems are fixed directly (more than 90% of the battery is out of these issues), such as a broken, plate series, shell, off grid hardware damage to repair leakage after repair can be a perfect value. Battery repair technology development: with the development of science and technology and the improvement of living standards, the battery has been used more and more to all areas of life, among them, especially in the electric car, car. Electric vehicles, the rapid development of auto industry, for the battery industry provides more broad prospects for development, but because people are in the process of using improper operation of some faults and battery, battery capacity, battery life significantly shortened, so the battery repair technology can develop. Battery technology to repair after adding acid method, large current charging method, water treatment, activated, scanning, broadband, high frequency, resonance, pulse, such as repair phase, of such technology are eliminated, the microcomputer is negative ion battery repair technology is more advanced, and compound ion repair technology, today's repair technology improvement. Look at my space also can point my name and mobile phone, the data in the above have the corresponding information and articles, there should be a help.

It is as you say, maintenance-free battery (battery) is as far as I know the following.

Remove the battery, and open in the middle of the plate, you can see 6 rubber cover. Take off the lid can see the charging port.

Extract the battery with the needle cylinder water, add 5 ml of each hole, and placed a day.

Without cover rubber sleeve with the charger, until each full (charger green light).

Cover the rubber cover, close the plastic sheeting.

The battery is not a long time under the premise of not bulge is useful, or save worry, changed directly.

Hope useful to you.

Battery is usually caused by sulfide capacity drops, the causes of sulfide are: long large current discharge, kui electric case form, and long-term let the battery in a losing electricity situation, water shortage, etc. Actually repair method is very much, your personal no professional repair equipment, only adding water for maintenance. Battery whether free maintenance of the dry battery or add water bottles of water and electricity, is needs to be maintained. Free maintenance is not without maintenance, just less frequent maintenance. General battery repair by battery repair and battery repair solution for battery repair. These you don't have to add water, simple maintenance. Water is a requirement, tap water and underground water and mineral water are not enough, or to use distilled water, deionized water, high pure water.

Electric car batteries are lead-acid batteries, there is no such thing as a one-off, cannot charge battery is a one-off.

Can add the battery solution, it is more troublesome, there are six cover plates, to pry open to all. Panasonic's cover design of the sealing is good, not to pry open.

Can repair, but Panasonic battery plate component and batteries are not quite same, longer service life, repair effect is not very good.

Open the battery cover, remove the six helmet.

How do we repair electric car battery?

For each hole with a syringe filled with distilled water, if add 1.28 standard electrolyte, plate may be because of the high spent acid soluble and burn out. Why, for example, we eat hot pot, the more you have, the more salty, that is to say, at the time of water evaporation, the salt is not by water vapor and evaporation, likewise, will not evaporate, battery acid is the lack of water, so we just join in each hole about 20-30 ml of distilled water. As shown in figure:

How do we repair electric car battery?

The battery still half an hour, after full plate around the sponge absorb moisture. Then with discharge resistance, the battery, after all, there is no resistance, can replace with a 12 v bulbs, such as: motorcycle headlights, car lights can, as long as you can have the effect of discharge to 0 v. How to judge whether a battery is nearly close to no electricity, cement resistance discharge resistor body hot at the beginning, slowly gradually is not hot, when the battery is the power went out. Light bulbs, more directly, as long as see light slowly not lit, means the end of the battery discharge, the discharge time depends on the battery discharge capacity, we can put the battery first ride to maintain when no electricity, so that we can shorten the time of discharge. As shown in figure:

How do we repair electric car battery?

After the discharge to recharge the battery, conditional can use pulse charging ways, because of the pulse charging method can effectively remove the plate vulcanizing, improve the capacity of the battery. No car can also charge to replace.

: (to the accumulator) as shown below in pulse charging, for example.

How do we repair electric car battery?

Charging is completed, with a syringe, each hole excess water. A total of 6 holes step by step to complete. As shown in figure:

How do we repair electric car battery?

Cover the hat and cap, can use loading.

To pry open the battery cover, because the coating glue general pry HouGaiBan are broken, just as well.

There were 6 holes, covered with a rubber cap, take it together with the surrounding white cotton adsorption.

Teach you how to repair the battery!

With a needle tube, each hole add 25 ml of supplementary fluid (depending on the individual battery fluid deficiency situation, pay attention to no more than the inside of the top plate or charging liquid will come out, because of charging liquid will boil, add more returned to smoke).Pay attention to the ventilation holes, or you don't go in.

Teach you how to repair the battery!

Wrap surrounding leakage, restore cap, and adsorb cotton. Wrap the battery in tape, and then you can use the battery for another 2 years.

The page contains the contents of the machine translation.